Optimización de los factores de hidrólisis ácida para obtener glucosa de los residuos de banano, cacao, palma africana y bagazo de caña de azúcar
Barra lateral del artículo
Contenido principal del artículo
Resumen
Biomass is an alternative to provide energy sources that replace fossil fuels. The objective of this investigation is to optimize the conditions of the acid hydrolysis reaction for obtaining glucose from biomass: banana rachis, cacao pod, African palm rachis, and sugarcane bagasse. The conditions were evaluated through a 2k experimental design. The factors studied were temperature, time, and acid concentration; the minimum and maximum levels correspond to 70 to 120 ◦C, 20 to 150 min, and 1% to 5% v/v, respectively. In addition, two replicates were made to the center. The best conditions for obtaining glucose were: 120 ◦C, 150 min and 1% v/v sulfuric acid. Sugarcane bagasse and African palm rachis were the biomasses from which the highest glucose content was obtained, 9 936.48 and 7 745.14 mg/L, respectively. The influence of biomass composition on the amount of glucose obtained is discussed.
Detalles del artículo
Esta obra está bajo una licencia internacional Creative Commons Atribución-NoComercial-CompartirIgual 4.0.
Universidad Politécnica Salesiana of Ecuador preserves the copyrights of the published works and will favor the reuse of the works. The works are published in the electronic edition of the journal under a Creative Commons Attribution/Noncommercial-No Derivative Works 3.0 Ecuador license: works can be copied, used, disseminated, transmitted and publicly displayed.
The undersigned author partially transfers the copyrights of this work to Universidad Politécnica Salesiana of Ecuador for the printed edition.
Referencias
Adsul, M., Sandhu, S.K., Singhania, R.R., Gupta, R., Puri, S.K. y Mathur, A. (2020) ‘Designing a cellulolytic enzyme cocktail for the efficient and economical conversion of lignocellulosic biomass to biofuels’, Enzyme and Microbial Technology, 133, 109442. Disponible en: https://doi.org/10.1016/j.enzmictec.2019.109442
Amirkhani, H., Yunus, R., Rashid, U., Salleh, S.F., Radhiah, A.B.D. y Syam, S. (2015) ‘Low-temperature dilute acid hydrolysis of oil palm frond’, Chemical Engineering Communications, 202(9), pp. 1235–1244. Disponible en: https://doi.org/10.1080/00986445.2014.918881
ASTM International (1956) ASTM D1104-56: Method of test for holocellulose in wood [Manual de software informático].
ASTM International (2021) ASTM D1107-21: Standard test method for ethanol-toluene solubility of wood [Manual de software informático].
Bali, S., Tofanelli, M.A., Ernst, R.D. y Eyring, E.M. (2012) ‘Chromium(III) catalysts in ionic liquids for the conversion of glucose to 5-(hydroxymethyl)furfural (HMF)’, Biomass and Bioenergy, 42, pp. 224–227. Disponible en: https://doi.org/10.1016/j.biombioe.2012.03.016
Duque, A., Álvarez, C., Doménech, P., Manzanares, P. y Moreno, A.D. (2021) ‘Advanced bioethanol production: From novel raw materials to integrated biorefineries’, Processes, 9(2), p. 206. Disponible en: https://doi.org/10.3390/pr9020206
Dussan, K., da Silva, D.V., Moraes, E., Arruda, P. y Felipe, M. (2014) ‘Dilute-acid hydrolysis of cellulose to glucose from sugarcane bagasse’, Chemical Engineering Transactions, 38, p. 433. Disponible en: https://doi.org/10.3303/CET1438073
Dutta, S. y Bhat, N.S. (2022) ‘Chemocatalytic value addition of glucose without carbon–carbon bond cleavage/formation reactions: an overview’, RSC Advances, 12(8), pp. 4891–4912. Disponible en: https://doi.org/10.1039/d1ra09196d
El-Zawawy, W.K., Ibrahim, M.M., Abdel-Fattah, Y.R., Soliman, N.A. y Mahmoud, M.M. (2011) ‘Acid and enzyme hydrolysis to convert pretreated lignocellulosic materials into glucose for ethanol production’, Carbohydrate Polymers, 84(3), pp. 865–871. Disponible en: https://doi.org/10.1016/j.carbpol.2010.12.022
Faba, L., Kusema, B.T., Murzina, E.V., Tokarev, A., Kumar, N., Smeds, A. y Díaz, E. (2014) ‘Hemicellulose hydrolysis and hydrolytic hydrogenation over proton- and metal-modified beta zeolites’, Microporous and Mesoporous Materials, 189, pp. 189–199. Disponible en: https://doi.org/10.1016/j.micromeso.2013.08.011
Hoang, A.T., Nizetic, S., Ong, H.C., Chong, C.T., Atabani, A.E. y Pham, V.V. (2021) ‘Acid-based lignocellulosic biomass biorefinery for bioenergy production’, Journal of Environmental Management, 296, 113194. Disponible en: https://doi.org/10.1016/j.jenvman.2021.113194
Kumneadklang, S., O-Thong, S. y Larpkiattaworn, S. (2019) ‘Characterization of cellulose fiber isolated from oil palm frond biomass’, Materials Today: Proceedings, 17, pp. 1995–2001. Disponible en: https://doi.org/10.1016/j.matpr.2019.06.247
Liu, C., Zhang, C., Liu, K., Wang, Y., Fan, G., Sun, S., … Li, Y. (2015) ‘Aqueous-phase hydrogenolysis of glucose to value-added chemicals and biofuels’, Biomass and Bioenergy, 72, pp. 189–199. Disponible en: https://doi.org/10.1016/j.biombioe.2014.11.005
Loow, Y.-L., Wu, T.Y., Jahim, J.M., Mohammad, A.W. y Teoh, W.H. (2016) ‘Typical conversion of lignocellulosic biomass into reducing sugars using dilute acid hydrolysis and alkaline pretreatment’, Cellulose, 23(3), pp. 1491–1520. Disponible en: https://doi.org/10.1007/s10570-016-0936-8
Loow, Y.-L., Wu, T.Y., Tan, K.A., Lim, Y.S., Siow, L.F., Jahim, J.M., … Teoh, W.H. (2015) ‘Recent advances in the application of inorganic salt pretreatment for transforming lignocellulosic biomass into reducing sugars’, Journal of Agricultural and Food Chemistry, 63(38), pp. 8349–8363. Disponible en: https://doi.org/10.1021/acs.jafc.5b01813
Lu, F., Rodriguez-Garcia, J., Van Damme, I., Westwood, N.J., Shaw, L., Robinson, J.S. y Warren, G. (2018) ‘Valorisation strategies for cocoa pod husk and its fractions’, Current Opinion in Green and Sustainable Chemistry, 14, pp. 80–88. Disponible en: https://doi.org/10.1016/j.cogsc.2018.07.007
Millati, R., Trihandayani y Cahyanto, M. (2011) ‘Ethanol from oil palm empty fruit bunch via dilute-acid hydrolysis and fermentation’, Agricultural Journal, 6, pp. 54–59.
Ministerio de Electricidad y Energía Renovable del Ecuador (2014) Atlas bioenergético del Ecuador. Disponible en: https://n9.cl/9x1ls
National Renewable Energy Laboratory (2008) Determination of structural carbohydrates and lignin in biomass (Inf. Téc. n.o NREL/TP-510-42618). NREL.
Odalanowska, M., Skrzypczak, A. y Borysiak, S. (2021) ‘Innovative ionic liquids as functional agent for wood-polymer composites’, Cellulose, 28(16), pp. 10589–10608. Disponible en: https://doi.org/10.1007/s10570-021-04190-1
Okolie, J.A., Nanda, S., Dalai, A.K. y Kozinski, J.A. (2021) ‘Chemistry and specialty industrial applications of lignocellulosic biomass’, Waste and Biomass Valorization, 12(5), pp. 2145–2169. Disponible en: https://doi.org/10.1007/s12649-020-01123-0
Oliveira, L., Cordeiro, N., Evtuguin, D.V., Torres, I.C. y Silvestre, A.J.D. (2007) ‘Chemical composition of different morphological parts from banana plant’, Industrial Crops and Products, 26(2), pp. 163–172. Disponible en: https://doi.org/10.1016/j.indcrop.2007.03.002
Roslan, N.S.H.C. y Salimi, M.N. (2020) ‘Glucose production from sugarcane bagasse by two stages chemical pretreatment and hydrolysis’, IOP Conference Series: Materials Science and Engineering, 743, 012037. Disponible en: https://doi.org/10.1088/1757-899X/743/1/012037
Samah, O., Sias, S., Hua, Y. y Hussin, N. (2011) ‘Production of ethanol from cocoa pod hydrolysate’, ITB Journal of Science, 43, pp. 87–94. Disponible en: https://doi.org/10.5614/itbj.sci.2011.43.2.2
Sathendra, E.R., Gurunathan, B. y Ramanujam, P.K. (2019) ‘Production of bioethanol from lignocellulosic banana peduncle waste’, Journal of Environmental Biology, 40, pp. 769–774. Disponible en: https://doi.org/10.22438/jeb/40/4(SI)/JEB_18
Shet, V.B., Sanil, N., Bhat, M., Naik, M., Mascarenhas, L.N., Goveas, L.C., … Aparna, A. (2018) ‘Acid hydrolysis optimization of cocoa pod shell using response surface methodology’, Agriculture and Natural Resources, 52(6), pp. 581–587. Disponible en: https://doi.org/10.1016/j.anres.2018.11.022
Sun, S., Sun, S., Cao, X. y Sun, R. (2016) ‘The role of pretreatment in improving the enzymatic hydrolysis of lignocellulosic materials’, Bioresource Technology, 199, pp. 49–58. Disponible en: https://doi.org/10.1016/j.biortech.2015.08.061
TAPPI (2002) T 212: One percent sodium hydroxide solubility of wood and pulp [Manual de software informático].
TAPPI (2006) T 222 om-02: Acid-insoluble lignin in wood and pulp [Manual de software informático].
Thompson, L.C., Ciesielski, P.N., Jarvis, M.W., Mukarakate, C., Nimlos, M.R. y Donohoe, B.S. (2017) ‘Estimating the temperature experienced by biomass particles during fast pyrolysis’, Energy & Fuels, 31(8), pp. 8193–8201. Disponible en: https://doi.org/10.1021/acs.energyfuels.7b00791
Yánez-Iñiguez, L., Urgilés-Urgilés, E., Zalamea-León, E. y Barragán-Escandón, A. (2020) ‘Potential from forestry waste for the contribution to the urban energy matrix’, La Granja: Revista de Ciencias de la Vida, 32(2), pp. 42–53. Disponible en: https://doi.org/10.17163/lgr.n32.2020.04
Yogalakshmi, K.N., Devi, P.T., Sivashanmugam, P., Kavitha, S., Kannah, Y.R., Varjani, S., … Banu, R.J. (2022) ‘Lignocellulosic biomass-based pyrolysis: A comprehensive review’, Chemosphere, 286, 131824. Disponible en: https://doi.org/10.1016/j.chemosphere.2021.131824
Yuan, X., Chen, X., Shen, G., Chen, S., Yu, J., Zhai, R., … Jin, M. (2022) ‘Densifying lignocellulosic biomass with sulfuric acid provides a durable feedstock’, Renewable Energy, 182, pp. 377–389. Disponible en: https://doi.org/10.1016/j.renene.2021.10.015